VW Sharan repair

. Diesel engines: 1,9 l of TDI.
+ 1. Introduction
+ 2. VR6 engine
+ 3. Two-liter engine (ADY)
+ 4. System of greasing of the engine
+ 5. Cooling system
- 6. System of injection of fuel of the VR6 engine
   6.1. Precautionary measures at work on repair of system of injection
   6.2. A principle of work of ESUD under various conditions
   + 6.3. Injection system
   + 6.4. Malfunctions of system of injection
   + 6.5. Work on repair and service of system of injection
   6.6. Cable of a drive of a butterfly valve
   + 6.7. Electric fuel pump
   6.8. Fuel filter
   6.9. The fuel level sensor in a tank
   6.10. Air filter
+ 7. Simos system of injection of fuel of the 2,0-liter engine
+ 8. Ignition system
+ 9. Coupling
+ 10. Mechanical 5-step transmission
+ 11. Shaft of a drive of wheels
+ 12. Hydraulic booster of a steering
+ 13. Forward suspension bracket
+ 14. Back suspension bracket
+ 15. Brake system
+ 16. Electric equipment
+ 17. Diesel engine
+ 18. System of greasing of the diesel engine
+ 19. System of cooling of the diesel engine
+ 20. Power supply system of the diesel engine and turbokompressor
+ maintenance Card
+ Specifications and characteristics
+ Elektroskhema




Repair Sharan/Sharan Volkswagen>> System of injection of fuel of the VR6 engine>> Air filter

Fig. 202. The air filter and the details located near it: 1 — the top part of the air filter; 2 — a vacuum hose; 3 — an O-shaped sealing ring; 4 — the sensor of a mass consumption of air; 5 — a shtekerny block for the sensor of a mass consumption of air, black color; 6 — a hose of let-in air; 7 — a shtekerny block, black color; 8 — a heating element of system of ventilation of a case; 9 — a connecting hose; 10 — the valve of system of ventilation of a case; 11 — a ventilating hose; 12 — a collar for (13); 13 — the electromagnetic valve of system of cleaning by means of absorbent carbon; 14 — a ventilating hose; 15 — a shtekerny block, green color for (13); 16 — the rubber coupling; 17 — a filtering element; 18 — the lower part of the air filter; 19 — an air inlet hose





Replacement of a filtering element 17 (see fig. 202 ) the air filter it is recommended to make each 60 000 km. However, if on the car trips on dusty and dirty roads are made, it is necessary to replace the filter earlier. Besides it is necessary to remove periodically the air filter and to blow it the compressed air, to remove large dirt.
Removal of the air filter carry out in the following order:
- remove a casing over the right headlight;
- open spring latches of the air filter;
- disconnect an air line;
- remove the top part of the case of the air filter;
- take filtering element;
- clear of dirt the case of the air filter a rag.