VW Sharan repair

. Diesel engines: 1,9 l of TDI.
+ 1. Introduction
+ 2. VR6 engine
+ 3. Two-liter engine (ADY)
+ 4. System of greasing of the engine
+ 5. Cooling system
+ 6. System of injection of fuel of the VR6 engine
+ 7. Simos system of injection of fuel of the 2,0-liter engine
+ 8. Ignition system
+ 9. Coupling
+ 10. Mechanical 5-step transmission
+ 11. Shaft of a drive of wheels
+ 12. Hydraulic booster of a steering
+ 13. Forward suspension bracket
+ 14. Back suspension bracket
+ 15. Brake system
- 16. Electric equipment
   + 16.1. Storage battery
   + 16.2. Generator
   + 16.3. Starter
   + 16.4. Screen wipers
   - 16.5. Headlights
      16.5.1. Replacement of lamps of headlights
      16.5.2. Removal and headlight installation
      16.5.3. Dismantling and headlight assembly
      16.5.4. Headlight adjustment
   16.6. Back lamps
   16.7. Replacement of lamps of forward indexes of turn
+ 17. Diesel engine
+ 18. System of greasing of the diesel engine
+ 19. System of cooling of the diesel engine
+ 20. Power supply system of the diesel engine and turbokompressor
+ maintenance Card
+ Specifications and characteristics
+ Elektroskhema








Repair Sharan/Sharan Volkswagen>> Electric equipment>> Headlights>> Removal and headlight installation
Removal of a headlight carry out in the following order:
- remove the turn index near a headlight (see подразд. 16.7);
- remove a front grille:
- unscrew four bolts of fastening of a front grille;
- squeeze out the top part of a front grille outside and remove it from the bottom fastening.
- in a motor compartment remove a protective cover of a headlight;
- disconnect the electric socket located from the back party of a headlight;
- in front unscrew four screws of fastening of a headlight (two from above and two from below) and remove a headlight assembled in the direction forward.
Installation of a headlight carry out as it should be, the return to removal. Pay attention to that the outer side of a headlight with directing densely adjoined to a wing edge. Tighten screws of fastening of a headlight the moment of 8 N · m. After installation of a headlight check and if necessary make adjustment of headlights. We recommend to make adjustment of headlights on HUNDRED.