VW Sharan repair

. Diesel engines: 1,9 l of TDI.
- 1. Introduction
   1.1. New VW Sharan
   1.2. Car identification
   1.3. General recommendations about car repairs
   1.4. Conditions of work and the used tool
   1.5. Correct lifting of the car
   - 1.6. Works on repair and service
      1.6.1. Check of level of engine oil and its replacement
      1.6.2. Check of level of brake liquid
      1.6.3. Check of work of stoplights
      1.6.4. Check of work of system of lighting
      1.6.5. Pressure check in tires
      1.6.6. Check of the air filter
      1.6.7. Check of level of cooling liquid
      1.6.8. Check of level of liquid in the hydraulic booster of a steering
   1.7. Lubricants, hermetics, Loctite
   1.8. Corrected addresses with carving connections, bolts, nuts
+ 2. VR6 engine
+ 3. Two-liter engine (ADY)
+ 4. System of greasing of the engine
+ 5. Cooling system
+ 6. System of injection of fuel of the VR6 engine
+ 7. Simos system of injection of fuel of the 2,0-liter engine
+ 8. Ignition system
+ 9. Coupling
+ 10. Mechanical 5-step transmission
+ 11. Shaft of a drive of wheels
+ 12. Hydraulic booster of a steering
+ 13. Forward suspension bracket
+ 14. Back suspension bracket
+ 15. Brake system
+ 16. Electric equipment
+ 17. Diesel engine
+ 18. System of greasing of the diesel engine
+ 19. System of cooling of the diesel engine
+ 20. Power supply system of the diesel engine and turbokompressor
+ maintenance Card
+ Specifications and characteristics
+ Elektroskhema








Repair Sharan/Sharan Volkswagen>> Introduction>> Works on repair and service>> Check of level of engine oil and its replacement
Oil level in the engine should be checked regularly through each 600 km, but is not more rare than once a week. The car thus should stand on an equal surface, and the idle engine should be still warm. If the engine hot, wait some minutes that oil flew down in the pallet.

Fig. 10. Shchup for measurement of level of oil in the engine





For check of level of oil take maslomerny щуп and wipe it a pure rag. Then again insert щуп on a place and once again pull out it. Level of oil should be between top and bottom risks. On щупе various markings (fig. 10) can be put .
Depending on level of oil it is necessary to arrive as follows:
- if level of oil is in area a limits, oil level in the engine corresponds to norm and to add it it is not required;
- if level of oil is in area b limits, amount of oil in the engine as a whole sufficient, but it is possible to add it to risks of b;
- if level of oil is in area with, it is necessary to add oil in the engine at least to level within area b.
Do not pour some oil above top risks as it can be sucked in in system of ventilation of a case and pollute the air filter and besides damage the catalyst. The 2,0-liter engine with the oil filter at replacement of oil will need 4,7 l, and for the VR6 engine (with the filter) — 5,5 l.
Through each 10 000 km or at least once a year it is necessary to make replacement of engine oil and the oil filter. Such periodicity of replacement of oil is considered normal at usual driving on the car. If it is necessary to go often with the trailer on dusty roads or to make short trips (7 — 8 km) at air temperature below zero, or often to stand in jams where the engine the long time works at single turns, replacement of oil should be made more often.
«Volkswagen» recommends oil which should correspond to norms of firm — No. 500 00 or 501 01. Surely make sure that filled-in oil corresponds to this norm.
Before replacement of oil establish the car on a platform, the lift or a viewing ditch. Remove a guard of protection of a case of the engine. Substitute capacity for collecting the fulfilled oil and turn out a screw drain stopper in the case pallet. To accelerate plums of oil uncover a jellied mouth for oil or pull out maslomerny щуп. Engine oil should be warm, but not hot. After plum of oil wipe a stopper of a drain opening rags and twist it. Fill in corresponding to requirements of the producer oil to normal level according to indications maslomerny щупа and replace the oil filter (replacement of the oil filter is described further).

Prevention
For concrete brand of the engine it is necessary to get the oil filter intended for this brand.